Carlisle EPDM Peel & Stick Cured Econo Flashing Tape – 6″

$179.99$539.99

Carlisle EPDM Peel & Stick Cured Econo Flashing Tape is a nominal .030″ (.75 mm) thick black cured EPDM membrane laminated to a nominal .035″ (0.89 mm) thick fully cured synthetic rubber peel and stick adhesive.

$179.99
$359.99
$539.99

Carlisle EPDM Peel & Stick Cured Econo Flashing Tape – 6″

Carlisle EPDM Peel & Stick Cured Econo Flashing Tape is a nominal .030″ (.75 mm) thick black cured EPDM membrane laminated to a nominal .035″ (0.89 mm) thick fully cured synthetic rubber peel and stick adhesive. Carlisle EPDM Peel & Stick Cured Econo Flashing Tape is available in 6” and 9” wide rolls and is used in applications that require a cured membrane to cured membrane seam. Carlisle EPDM Peel & Stick Cured Econo Flashing Tape is ideal for stripping in seams, metal edge details (flat), or simple repairs to cut membrane. The cured state of the EPDM membrane enables it to handle expansion and contraction loads without weakening and allows it to resist tearing, flex cracking, and abrasion and other forms of deterioration caused by temperature extremes, sunlight, precipitation, and all forms of normal weathering.


Key Features

  • Available in 6″ and 9″ wide rolls


Installation

1. The entire surface where the Carlisle EPDM Peel & Stick Cured Econo Flashing Tape will be applied must be clean. The adhesive on the back of the Carlisle EPDM Peel & Stick Cured Econo Flashing Tape will not adhere to dusted/dirty surfaces. Any residual contamination will be detrimental to the bond strength of the adhesive.
2. Remove all foreign material.
a. Remove excess mica dust by brooming or wiping with a clean, dry rag.
b. The use of Membrane Cleaner may be necessary. This process is essential on membrane that has been exposed for a number of weeks. Note: Permeation-resistant gloves (that meet ANSI/ ISEA 105-2005) are required for hand protection when cleaners or primers are being used.
c. Allow the membrane to dry thoroughly before proceeding.
3. Application of EPDM Primer:
a. Standard Membrane: Apply the primer using a clean rag. Scrub the area of the membrane where the Carlisle EPDM Peel & Stick Cured Econo Flashing Tape is to be applied in a circular motion to achieve a thin, even coating on the membrane. The properly cleaned/primed area will be uniform in color without streaks and free of globs or puddles.
b. No-Dust Membrane: Roller-apply the primer to the membrane with a short nap-length paint roller. The coated area will be free of globs or puddles. Note: The use of excessive amounts of primer will not significantly enhance the adhesion of the Carlisle EPDM Peel & Stick Cured Econo Flashing Tapet to the EPDM membrane. Use only the amount necessary to obtain 100% coverage of the area where the Carlisle EPDM Peel & Stick Cured Econo Flashing Tape will be applied.
4. Allow the primer to flash off until it does not transfer to a dry finger touch yet remains tacky. Install Carlisle EPDM Peel & Stick Cured Econo Flashing Tape immediately after the primer has fl ashed off to promote adhesion and avoid contamination.
5. Peel off 10-12″ (250-305 mm) of the protective release liner from the Carlisle EPDM Peel & Stick Cured Econo Flashing Tape. Position the cured cover tape over the area to be covered and press down the exposed tape adhesive using firm, even hand pressure across the entire area. Continue this process until the full area to be fl ashed is completed.
6. Immediately roll the Carlisle EPDM Peel & Stick Cured Econo Flashing Tape with a 2″-wide (50 mm) roller. Roll across the cover strip edge, not parallel to it.
7. Apply Lap Sealant at overlaps in Carlisle EPDM Peel & Stick Cured Econo Flashing Tape or at joints in the metal edging according to the appropriate detail.
8. To achieve proper adhesion of the Carlisle EPDM Peel & Stick Cured Econo Flashing Tape when jobsite temperatures fall below 40ºF (4ºC), heat the primed area of the membrane with a hot-air gun as the fl ashing is applied and pressed into place.


Downloads

PDF File: Carlisle EPDM Peel & Stick Cured Econo Cover Tape